RV Trailer – leakage prevention and Repairing

Most metal roofs are made from sheets, held into place by sheet metal screws. These screws should be sealed annually in order to help prevent leakages from these points. The roof of your mobile home and sometimes the body will flex and move while the unit is being transported, and this can cause cracks and distortions, leading to leaks. Seal the sheet metal screws with a plastic or flexible rubber coating and be sure to repeat this job every year.

RV roofs need repair

RV Roof Repair Solutions

Newer RV trailer and mobile home roofs may have a rubber sheet that covers the aluminum roof sheets to help with waterproofing the metal roof. For this, a yearly inspection and good preventative maintenance is vital if you want to keep the roof in perfect condition. There are many kinds of products available that are designed especially for this kind of roof, products that can prevent damage and repair the rubber covering material. When using these products, be sure to pay attention to the areas near your roof mounted air conditioning unit, as well as other vents on the roof, for example air vents, gas refrigerator vents and plumbing fixtures. It’s also possible to buy kits for replacing the rubber roof material at most mobile home dealers and suppliers. However, preventative measures are always the most practical idea. Applying a decent sealant to your roof once a year can save you possibly thousands of dollars.

Roof and Ceiling Inspection

One of the most destructive problems that are faced by mobile home owners is that of leaky roofs. If it goes unnoticed, then the leak and damage will slowly spread through to other parts of your mobile home, including possibly its walls and floor structure, causing severe damage.

Therefore, it is vitally important that owners carry out regular inspections of their mobile home roofs. A regular inspection means 4 or 5 times a year, or even more if you can. One of the reasons you need to inspect it so often  is that, especially in the case of someone who doesn’t live permanently in their RV Trailer, there might not be anyone around to notice the roof leaking for quite some time, by which time the ceiling may already be stained and irreparable damage caused.

A thorough inspection of an RV trailer roof is not a five minute job. Be prepared to invest some time carefully checking your roof so that you don’t miss anything. Any roof inspection should include such necessities as checking inside the mobile home as well. Be sure to inspect the walls on the inside where the roof sheets are connected to the edges of these walls. This might mean you have to open closets and cabinets in order to properly check every part. The thing you are looking for during these checks is any sign of dampness or water damage to the walls and/or fittings in the home.

Ceiling discoloration or staining might well be an indication that there is a leakage somewhere on the roof. Check the discoloration carefully. If it is only slight, then the leak is unlikely to be a major one and can probably be fixed with by simply applying a sealant. If the discoloration is particularly bad though, or if you can see any rotten or mildewed wood, then this is a sure sign of a serious leak, and the need for major repairs is likely.

RV camper rubber roof

RV Roof Repair Kits

During your inspections, make sure that you check the top of your mobile home to learn the locations of all the air vents, air conditioning vents and anything else that will require waterproofing. All of these points are common sources of leaks in a mobile home roof. All of these items should be checked both inside and outside for any signs of leakages.

Most mobile home roofs make use of vinyl strips, to waterproof the screws in the roof. Be warned that these vinyl strips do not last forever and will need replacing after a few years. Eventually, they will come unstuck and fall from their retaining grooves. You can buy replacement vinyl strips at most mobile home camp sites, as well as many garages and dealerships. Leaks from these screws can be almost undetectable and so it’s advisable to replace all of the strips on a roof completely after 5 years, even if they look fine.

Another common leakage that is difficult to find is leaks that are close to the running lights. The lights are sealed with a rubber gasket that fixes it to the body of the mobile home. These areas have to be checked very carefully, as the rubber gasket can wear out after some time. If you notice a leak here, you can either buy a replacement gasket, or perhaps more conveniently, seal the leakage with a silicone caulk. If undetected, a leak here could cause some serious deterioration to the walls and floor of your mobile home.

Repairing Holes and Leaks

Once you have found the source of the leak, you’ll need to patch it up as soon as possible to prevent any more damage. For holes that are bigger than one inch in diameter, it is usually best to use a piece of aluminum sheeting to cover it with. To do this, you need to cut out a piece of the sheeting that is larger than the hole in the roof. Make sure you have plenty of bearing so that you can cover the hole completely. Secure the aluminum sheet to the roof, over the hole, with self taping screws that can be driven straight into the roof. Then, to seal the sheet so it’s watertight, use a putty tape around the edges or some kind of non-hardening putty, making sure there are no gaps left at the edges of the sheet at all.

Smaller sized holes can be fixed more easily, using a sticky aluminum tape, for example Peel N Seal repairing tape. Simply clear all debris away from the hole, clean the surface where you are going to stick the tape, and finally seal the hole, making sure the tape is stuck down very firmly and there are no gaps visible.

If you do not carry out regular maintenance on your mobile home roof, you are running a huge risk. If left too late, then repairing the roof of your mobile home or RV camper rubber roof can cost upwards of several thousand dollars and all because you failed to spot a small leak in time.

Preventative maintenance can save you an awful lot of money in the long run, it’s easy to perform, and very inexpensive. You don’t even need to have any real skills to do it. Mobile homes need care and attention just as much as our real homes do. If you love your mobile home and take care of it, then your mobile home will take good care of you.

  • Julio

    Large fan with this website, a lot of your articles have seriously helped me out. Awaiting upgrades!

  • best rolex knockoffs

    and understated elegance for those who are leaders in their field and demand perfection and only that!

  • Tudur

    I stumbled in your webpage by incident when searching Yahoo and I’m glad I did. Your post is mostly a little bit several and I appreciated perusing it. I’ll consequently generate a comment about it on my blog and stage my site visitors your way. Thanks.

  • Elsa

    nice information, many thanks to the author. it is incomprehensible to me now, but in general, the usefulness and significance is overwhelming. thanks again and good luck!

  • cedar shake roof repair

    I like the helpful info you supply in your articles. I will bookmark your weblog and take a look at again here regularly. I am reasonably sure I’ll be informed plenty of new stuff right here! Best of luck for the next!

  • air conditioning contractor

    Great post. I was checking constantly this weblog and I am impressed! Extremely helpful info specifically the ultimate section :) I take care of such info a lot. I was seeking this certain info for a very long time. Thanks and best of luck.

  • http://www.genesishealthinstitute.com/testosterone.php

    That is very helpful. It provided me a few ideas and I’ll be posting them on my web site eventually. I’m bookmarking your site and I’ll be back again. Thank you again!

  • Pranie dywanów Warszawa

    Saved as a favorite, I really like your blog!

  • Pranie wykładzin Warszawa

    Having read this I believed it was very informative. I appreciate you finding the time and effort to put this short article together. I once again find myself personally spending way too much time both reading and commenting. But so what, it was still worth it!

  • Pranie dywanów Warszawa

    After research just a few of the blog posts in your website now, and I truly like your approach of blogging. I bookmarked it to my bookmark website list and will probably be checking again soon. Pls take a look at my website online as well and let me know what you think.